Use LEFT and RIGHT arrow keys to navigate between flashcards;
Use UP and DOWN arrow keys to flip the card;
H to show hint;
A reads text to speech;
29 Cards in this Set
- Front
- Back
Reduction Gears Pressure Engaged
|
Normal - 186-265psi
Disabling – Less than 186psi or More than 265psi |
|
Reduction Gears Pressure Disengaged
|
Normal – 15-65psi
Disabling - Less than 15psi or More than 65psi |
|
Reduction Gears Temperature
|
130-185F
|
|
Type Lube Oil
|
15W40
|
|
Type Hydraulic Oil
|
AW32
|
|
Hydraulic Oil Capacity
|
9 Gal
|
|
Engine Oil Capacity
|
43 Qts. – 10.75 Gal
|
|
Reduction Gear Lube Oil Capacity
|
2.8 Gal
|
|
Lube Oil PSI @ 2300RPM
|
Normal: Greater than 41 psi
Disabling: Less than 31 psi Alarm: Sounds at 30 psi |
|
Reduction Ratio
|
1.02:1
|
|
CODE 44
|
High Water Temp
|
|
CODE 45
|
Low Lube Oil
|
|
Jacket Water Temps
|
Normal: 140-185*F
Restrictive: 186-211*F Disabling/Alarm: 212*F |
|
Jacket Water Capacity/Type
|
12 Gallons of Power Cool 50/50 pre-blend
|
|
Engine lube oil pressure below 10 psi at 650 RPM
|
Disabling Casualty
|
|
Engine lube oil pressure below 31 psi at 2300-2350 RPM
|
Disabling Casualty
|
|
Reduction gear oil temperature above 193F at 2300-2350 RPM
|
Disabling Casualty
|
|
Engine coolant temperature between 186F and 211F.
|
Restrictive Casualty
|
|
Leaks less than 15 drops per minute:
a) Jacket Water b) Raw Water c) Lube Oil d) Hydraulic Fluid e) Marine Gear Oil |
Major Discrepancy
|
|
Any fuel leak (piping/fittings/tank) that drips less than one drop within ten minutes.
|
Major Discrepancy
|
|
Loose/missing fittings, nuts, bolts, brackets, etc.:*
a) Hardware on the engines used for attaching equipment. b) Battery terminals loose or corroded. c) ECM cables loose or disconnected. * For fasteners utilizing nyloc nuts, the bolt must engage and pass through the nylon insert, but not more than five threads. |
Major Discrepancy
|
|
Leaks more than 15 drops per minute:
a) Jacket Water b) Raw Water c) Lube Oil d) Hydraulic Fluid e) Marine Gear Oil |
Restrictive Casualty
|
|
Fuel oil dripping* (falling onto a surface which is not hot). One drop within ten (10) minutes
|
Restrictive Casualty
|
|
Fuel oil dilution 2.5% or above.
|
Disabling Casualty
|
|
Complete loss of charging system. (i.e. both AuraGens inoperative)
|
Disabling Casualty
|
|
Complete steering system inoperative.
|
Disabling Casualty
|
|
Failure of any emergency system:
a) Fuel shut off valves do not fully close |
Restrictive Casualty
|
|
Maximum RPM under load (norm 2300) – less than 2200 RPM.
|
Restrictive Casualty
|
|
CODE 48
|
Low Fuel Oil PSI
|